Product ID:4032 TRIM ADHESIVE
MSDS Date:09/01/1992
FSC:8040
NIIN:00F031573
MSDS Number: BSNRN

MARTIN-SENOUR CO

101 PROSPECT AVE N.W.
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: MART2

MARTIN-SENOUR CO

CLEVELAND, OH 44115 US

Telephone: 216-566-2902

Cage: MART2

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 14%

OSHA PEL 1000 PPM

ACGIH TLV: SIMPLE ASPHYXIANT

ISOBUTANE, 2-METHYLPROPANE

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 60%

OSHA PEL 1800 MG/CUM

ACGIH TLV: 1000 PPM

HEXANE, N-HEXANE

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: <17%

OSHA PEL 1800 MG/CUM

ACGIH TLV: 176 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

HEXANE ISOMERS

RTECS: MO3860000

Fraction By Weight: <17%

OSHA PEL 50 PPM

ACGIH TLV: 500 PPM

DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSPECTED HUMAN

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 32%

OSHA PEL 100 PPM

ACGIH TLV: 174 MG/CUM (A2)

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICON DIOXIDE, CELITE 322

CAS: 7631-86-9

RTECS: VV3100000

Fraction By Weight: 1%

OSHA PEL 80 MG/CUM

ACGIH TLV: 0.2 MG/CUM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:IRRITATION OF EYES/SKIN/RESPIRATORY
SYSTEM. CNS DEPRESSION. PROLONGED SOLVENT MAY CAUSE ADVERSE EFFECTS
TO LIVER/URINARY/BLOOD FORMING/REPRODUCTIVE/CARDIOVASCULAR
SYSTEMS/PERMANENT BRAIN/CNS DAMAGE. H EXANE MAY CAUSE PERIPHERAL
NERVE DAMAGE. EXTREME OVEREXPOSURE MAY CAUSE UNCONSCIOUSNESS &
POSSIBLY DEATH.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION:
HEADACHE/DIZZINESS/NAUSEA/COORDINATION LOSS/UNCONSCIOUSNESS/DEATH.
SKIN/EYES: REDNESS/ITCH/BURNING SENSATION. HEXANE: (PERIPHERAL
NEUROPATHY) MUSCULAR WEAKNESS, LOSS OF SENSATION. OVEREXPO SURE TO
METHYLENE CHLORIDE CAN RAISE THE LEVEL OF CARBON MONOXIDE IN THE
BLOOD.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. REMOVE CONTAMINATED
CLOTHING. EYES: FLUSH W/PLENTY OF WATER FOR 15 MINUTES. INGESTION:
OBTA IN MEDICAL ATTENTION IN ALL CASES.

Flash Point:<0F
Lower Limits:0.5%
Upper Limits:7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE SCBA. WATER SPRAY: INEFFECTIVE. FOG
NOZZLES PREFERRED. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILDUP/AUTOIGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:HEAT FROM SUNLIGHT, RADIATORS, STOVES,
HOT WATER & OTHER HEAT SOURCES COULD CAUSE CONTAINER TO BURST.
FLAMMABLE.

Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA/REMOVE
W/INERT ABSORBENT.

Handling and Storage Precautions:USE ONLY IN ADEQUATE VENTILATION. KEEP
AWAY FROM HEAT, SPARKS, OPEN FLAME. DURING USE & UNTIL ALL VAPORS
ARE GONE; KEEP ARE VENTILATED. DON'T SMOKE.
Other Precautions:EXTINGUISH ALL FLAMES, PILOT LIGHTS & HEATERS. TURN
OFF STOVES/ELECTRIC TOOLS/APPLIANCES & OTHER IGNITION SOURCES.
CONSULT NFPA CODE. USE APPROVED BONDING/GROUNDING PROCEDURES.
CONTENTS UNDER PRESSURE . KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
TLV BY VENTILATION, USE A FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING DRIED
FILM, USE A NIOSH/MSHA DUST/MI ST RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIALS IS MAINTAINED BELOW APPLICABLE LIMITS.
Protective Gloves:REQUIRED
Eye Protection:SAFETY GLASSES W/UNPERFORATED SIDESHIELD
Work Hygienic Practices:WASH HANDS AFTER USING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
COATING MAY CONTAIN MATERIALS CLASSIFIED AS NUISANCE PARTICULATES WHICH
MAY BE PRESENT AT HAZARDOUS LEVELS ONLY DURING SANDING/ABRADING OF
DRIED FILM. DON'T PUNCTURE, INCINERATE OR EXPOSE TO TEMPS >12 0F.
DON'T TAKE INTERNALLY. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING/INHALING CONTENTS CAN BE HARMFUL/FATAL.

Boiling Pt:B.P. Text:<0-395F
Vapor Density:>1
Spec Gravity:0.75-0.91
Solubility in Water:INSOLUBLE
Percent Volatiles by Volume:>50

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT/SPARKS/OPEN FLAMES/PILOT LIGHTS &
OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO2, CO

Waste Disposal Methods:PRODUCT WASTE MAY BE HAZARDOUS AS DEFINED UNDER
THE RCRA. TEST WASTE FOR IGNITABILITY TO DETERMINE THE APPLICABLE
EPA HAZARDOUS WASTE NUMBERS. DON'T INCINERATE. DEPRESSURIZE
CONTAINER. DISPOSE OF IN A CCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.